Ford Fusion Questions - 2014 FORD FUSION FUEL PUMP LOCATION (2024)

FAQs

Where is the fuel pump located on a 2014 Ford Fusion? ›

The fuel tank is located under the rear seat cushion, left side and you should be able to access the fuel pump from the top.

This car has two fuel pumps, the low-pressure pump in the fuel tank and the high-pressure pump on the engine.

The average cost for a Ford Fusion Fuel Pump Replacement is between $783 and $890. Labor costs are estimated between $226 and $285 while parts are priced between $557 and $605. This range does not include taxes and fees, and does not factor in your unique location. Related repairs may also be needed.

Unfortunately, the 2014 Ford Fusion was prone to have issues with its fuel system. Some most commonly reported fuel issues are stalling, poor fuel economy, and sloshing fuel noises. Many owners have reported issues with the Fusion stalling or choking, which was accompanied by a weird noise from the fuel tank.

Most cars have an in-tank pump mounted within the fuel tank, although some have an inline pump located between the gas tank and the engine.

The fuel filter is positioned in the line leading from the gas tank to the engine and prevents containments from getting inside the engine, which could lead to a loss in performance and potential damage to the cylinder lining.

A faulty fuel pump may be the reason for struggling to maintain speed, engine overheating, sputtering, or the “check engine” light illuminating. Fuel pump replacement is moderately complicated and may involve removing the fuel tank if no access panel exists in the passenger compartment.

That is why we've issued a recall for certain 2019–2020 Ford Fusion Energi Plug-in Hybrid models. There is a chance a fire may break out in the trunk area while driving, increasing the risk of injury. We are asking you to please avoid charging your vehicle until a remedy is available.

How long does it take to replace a fuel pump? In most cases, around two to three hours. However, job times can vary widely depending on how easy it is to access the pump. The fuel pump sits inside the fuel tank, and is attached to a plate on the top of the tank.

How much does it cost to replace a fuel pump on a 2014 Ford Focus? ›

A typical fuel pump replacement in the UK costs around £248 - £389.

Your vehicle's fuel pump should last at least 100,000 miles or more. If it doesn't, or if you've exceeded that mileage milestone, you may notice any of the following seven signs.

Ford Motor Company is issuing a safety recall for select 2014-15 Ford Fiesta, 2014-16 Ford Fusion and 2014-16 Lincoln MKZ vehicles. In affected vehicles, the latch pawl spring-tab design is susceptible to cracking and failure in areas with high ambient temperatures.

The most common cause of engine sputtering are issues with the fuel system. These can range from bad fuel filters, fuel pump issues, or fuel injector issues. The other possible source of the problem would be due to poor ignition - think spark plugs or ignition coil problems.

2014 Ford Fusion: Quick Overview

New features for the 2014 model year include a 1.5L EcoBoost engine, a heated steering wheel, and ventilated front seats. Reliability ratings are average, according to J.D. Power. The 2014 model still has engine problems, but they're not as widespread as they were in 2013.

There is no fuel filter on a 2014 Fusion. The only filtration is the filter that is attached to the fuel pump inside the fuel tank.

This mechanical engine driven pump is bolted directly to an accessory pad on the engine crankcase from whence it delivers the fuel under pressure to the fuel injector or carburetor.

Located inside your fuel tank, a fuel pump has a small electric motor to make sure that pressurized gasoline flows to the engine to power the vehicle.

Electric pumps

In fuel-injected petrol engines, an electric fuel pump is typically located inside the fuel tank. For older port injection and throttle-body injection systems, this "in-tank" fuel pump transports the fuel from the fuel tank to the engine, as well as pressurising the fuel to typically 40–60 psi (3–4 bar).